Fitting a new water tank gauge
Practical Boat Owner|Summer 2021
Measuring your boat’s water capacity is essential for any cruiser, yet is surprisingly hard to get right, discovers Roger Hughes
Roger Hughes
Fitting a new water tank gauge

Boats are likely to have many instruments aboard, and one of the most useful is that which indicates the exact amount of fresh water in the tanks, especially if the boat doesn’t have a watermaker. But accurate water gauge reading has been a problem on every yacht I have owned.

My 45ft schooner Britannia has two stainless steel fresh water tanks amidships, one on each side. Like most yachts the outer shape follows the curve of the hull and the tanks are therefore broadly triangular-shaped in cross-section, tapering to a point at the bottom.

This shape makes accurate calibration of water capacity difficult for most electronic measuring devices: when the device in the tank measures the water halfway down the vertical side of the tank, the actual capacity is much less than half – only about a third in Britannia’s case.

The remedy would have been quite simple, if somewhat crude, had my system actually worked. It would have just been a question of first determining the exact volume of water in the tanks by draining and refilling, using a flow meter. Then divide the total by four to give one-quarter, half, three-quarters and full. Then refill one quarter at a time, marking the gauge accordingly.

The original system was – note the past tense here – pneumatic (air) operated, which works on the pressure differential as the water level in the tanks varies. It is a simple concept having only two components, and no electrics other than illumination of the gauge. Just the job for a cruising yacht you might think.

This story is from the Summer 2021 edition of Practical Boat Owner.

Start your 7-day Magzter GOLD free trial to access thousands of curated premium stories, and 8,500+ magazines and newspapers.

This story is from the Summer 2021 edition of Practical Boat Owner.

Start your 7-day Magzter GOLD free trial to access thousands of curated premium stories, and 8,500+ magazines and newspapers.

MORE STORIES FROM PRACTICAL BOAT OWNERView All
Shearwater sloop sailing in the 1960s
Practical Boat Owner

Shearwater sloop sailing in the 1960s

Genevieve Leaper shares her late father John Leaper's recollections-compiled from handwritten notes-of cruising the Channel

time-read
7 mins  |
November 2023
Timing an Atlantic crossing
Practical Boat Owner

Timing an Atlantic crossing

Professional meteorologist and sailor Chris Tibbs shares his knowledge of how to choose the best time to sail 'across the pond'

time-read
5 mins  |
November 2023
Transatlantic first
Practical Boat Owner

Transatlantic first

It's 70 years since Ann Davison became the first woman to sail solo across the Atlantic. Katy Stickland looks back at her achievement

time-read
5 mins  |
November 2023
Going dizzy on an island sailing odyssey
Practical Boat Owner

Going dizzy on an island sailing odyssey

Ken Fowler becomes the first sailor to circumnavigate every island in England and Wales-and all done in a 4m dinghy!

time-read
10+ mins  |
November 2023
Boats for coastal cruising
Practical Boat Owner

Boats for coastal cruising

Duncan Kent chooses a selection of the best sail and motor boats under 40ft most suitable for adventurous cruising along the coast

time-read
10+ mins  |
November 2023
Industry view on HVO
Practical Boat Owner

Industry view on HVO

The RYA, IWA and CA are working to help recreational boating transition to a Net Zero future, as the CA's

time-read
2 mins  |
November 2023
HVO RENEWABLE DIESEL Myth or miracle?
Practical Boat Owner

HVO RENEWABLE DIESEL Myth or miracle?

A new generation of biofuel that's cleaner, greener, better for your engine and less prone to microbial growth sounds too good to be true... but the facts beg to differ

time-read
8 mins  |
November 2023
Little ships and the wrong sort of waves
Practical Boat Owner

Little ships and the wrong sort of waves

Why the correct manoeuvres for the sea conditions will reduce hogging and sagging stress on both ship and crew

time-read
5 mins  |
November 2023
Watching boats, saving jerseys
Practical Boat Owner

Watching boats, saving jerseys

It's amazing what you can see from a hospital window if it's the right hospital

time-read
3 mins  |
November 2023
Sweating the mooring asset
Practical Boat Owner

Sweating the mooring asset

Sam Llewellyn looks at ways of getting top value out of his boat's swinging mooring

time-read
3 mins  |
November 2023